mot decat issues
#31
Scooby Regular
2002 Prodrive Bug, 2003 JDM Blob. Both fully decatted. 3” Turbo back. Both fly through their MOT. Goes to a local garage for a “pre MOT”, they take it to MOT centre directly opposite their premises. £53 later MOT Cert in hand. To OP it may be worth finding another S’netter in your area and PM them. See if they can point you in the direction of someone more (MOT) user friendly. Prob best not to disclose it publically because it could ruin a good thing for all!
#32
Scooby Regular
Thread Starter
Think you may have failed due to the rule that if a cat was present when the vehicle was new it needs to be in place, technically a ppp pack could fail if this rule is taken to the extreme, however a ppp centre decat still has the heat shields in place so looks like a standard section, hence most mot stations wouldn’t know anyway,
you could always fit cat shields to a decat pipe as per ppp then would probably be ok. And technically a sport cat could fail as it probably hasn’t got the correct eu type approval code on it. Most are sold as off road only.
you could always fit cat shields to a decat pipe as per ppp then would probably be ok. And technically a sport cat could fail as it probably hasn’t got the correct eu type approval code on it. Most are sold as off road only.
#35
Scooby Regular
Guess you didn't check the Pre 2002 engine swap loophole ? as it turns out your wrong and it's possible
It's not a grey area it's there in black & white, do a legit engine swap on a car pre Sep 2002 and its tested to whichever is oldest, chassis or engine
Only going on because you were so sure i was wrong, yet turns out i was correct
#36
Scooby Regular
iTrader: (6)
Yea least your right about that
Guess you didn't check the Pre 2002 engine swap loophole ? as it turns out your wrong and it's possible
It's not a grey area it's there in black & white, do a legit engine swap on a car pre Sep 2002 and its tested to whichever is oldest, chassis or engine
Only going on because you were so sure i was wrong, yet turns out i was correct
Guess you didn't check the Pre 2002 engine swap loophole ? as it turns out your wrong and it's possible
It's not a grey area it's there in black & white, do a legit engine swap on a car pre Sep 2002 and its tested to whichever is oldest, chassis or engine
Only going on because you were so sure i was wrong, yet turns out i was correct
I actively encourage you to put an older engine into your car and take it to an MOT station. The MOT station will only be able to test the vehicle based on the information on the VOSA database, which if you haven't informed the DVLA and VOSA will show the old engine... still requiring an emissions test.
If you do tell the DVLA then they will want a full mechanical report submitted and then VOSA will want to inspect your vehicle before they even contemplate changing their records and database on engine type. It will probably then be classed as a special somehow and MAY be bound to different regulations. Who knows!
#38
18 June 1815 - Waterloo
iTrader: (31)
Yea least your right about that
Guess you didn't check the Pre 2002 engine swap loophole ? as it turns out your wrong and it's possible
It's not a grey area it's there in black & white, do a legit engine swap on a car pre Sep 2002 and its tested to whichever is oldest, chassis or engine
Only going on because you were so sure i was wrong, yet turns out i was correct
Guess you didn't check the Pre 2002 engine swap loophole ? as it turns out your wrong and it's possible
It's not a grey area it's there in black & white, do a legit engine swap on a car pre Sep 2002 and its tested to whichever is oldest, chassis or engine
Only going on because you were so sure i was wrong, yet turns out i was correct
Putting a fresh apple in a bowl of rotting fruit changes sweet FA.
#39
Scooby Regular
Dunno which part of this confuses folk
#40
Scooby Regular
LOL. If you say so, but I know for a fact I'm right and I'm bored with this pointless debate now anyhow. I have friends who own their own MOT stations and friends who are testers. Putting an older engine into a car doesn't mean you make the car itself older.
I actively encourage you to put an older engine into your car and take it to an MOT station. The MOT station will only be able to test the vehicle based on the information on the VOSA database, which if you haven't informed the DVLA and VOSA will show the old engine... still requiring an emissions test.
If you do tell the DVLA then they will want a full mechanical report submitted and then VOSA will want to inspect your vehicle before they even contemplate changing their records and database on engine type. It will probably then be classed as a special somehow and MAY be bound to different regulations. Who knows!
I actively encourage you to put an older engine into your car and take it to an MOT station. The MOT station will only be able to test the vehicle based on the information on the VOSA database, which if you haven't informed the DVLA and VOSA will show the old engine... still requiring an emissions test.
If you do tell the DVLA then they will want a full mechanical report submitted and then VOSA will want to inspect your vehicle before they even contemplate changing their records and database on engine type. It will probably then be classed as a special somehow and MAY be bound to different regulations. Who knows!
From the M.O.T Inspection Manual 2012,
Also see the part where i tell you that you must register it as running the older engine,
"I was under the impression that if it is a legit engine swap DVLA notified then engine is tested to rules of its year and not the chassis its fitted to"
My point was valid and you just disregarded it as if nonsense,
Sure you will need to do it legit but i says that.......
#45
Scooby Regular
Thread Starter
anyway mine failed, so someone is right , after all the discussion I'm not sure who. lol. but mines in the garage awaiting a new mid section to get an MOT
#47
Scooby Regular
if you were near me I would tell you where to go to avoid all this hassle. If your doing the centre section purely for MOT only to change back again that has to be close to £300 (very rough figure) each MOT time! No disrespect intended but that seems an avoidable expense & pain in the rear.
#48
Scooby Regular
iTrader: (6)
Also it's worth baring in mind that the further the cat gets away from the turbo the cooler it runs and the less efficient it works. The cat needs to get to 400degC for it to work effectively and pass mot emissions. This is why sports cats are normally in the downpipe and not further down the system.
I have a friend with a forester STI which was Ian Litchfields own development car years ago. He's got a decat downpipe and a cat after that and it just won't pass mot like that, just doesn't get hot enough.
worth bearing in mind.
I have a friend with a forester STI which was Ian Litchfields own development car years ago. He's got a decat downpipe and a cat after that and it just won't pass mot like that, just doesn't get hot enough.
worth bearing in mind.
#49
Scooby Regular
iTrader: (5)
My local mot tester told me he had no way of telling whether exhausts were oem or not, if he could even see them, due to undertrays. All he is interested in is " do they pass emissions? ".
"Friendly" testers have everything to lose and nothing to gain by passing decats , and in my experience, all testers seem to take great pride and joy in finding fails, so unless someone can pm me the name of a legendary friendly tester between Cornwall and Kent, I'm going to file the subject under" urban mot legends" Unless they are your best mate.....
"Friendly" testers have everything to lose and nothing to gain by passing decats , and in my experience, all testers seem to take great pride and joy in finding fails, so unless someone can pm me the name of a legendary friendly tester between Cornwall and Kent, I'm going to file the subject under" urban mot legends" Unless they are your best mate.....
#50
Scooby Regular
Thread Starter
Scoobydooooo sorry if this sounds a bit harsh but you really need let people know where you are from if you want to avoid all this. Surely you do not want to keep going through this at MOT time? Or are you now going to have new centre section and remap and leave it alone? Because it will really need remapping if you are going from a decatted system to putting a cat back in for emissions reasons? All that just for an MOT when a bit of local knowledge goes a long way.
if you were near me I would tell you where to go to avoid all this hassle. If your doing the centre section purely for MOT only to change back again that has to be close to £300 (very rough figure) each MOT time! No disrespect intended but that seems an avoidable expense & pain in the rear.
#51
Scooby Newbie
Join Date: Sep 2017
Location: Northern ireland
Posts: 4
Likes: 0
Received 0 Likes
on
0 Posts
So what are the emissions limits for 2004 Blob JDM import ? Does it get a more lenient test?
my friend has a 3 inch full system (no cats) but decided to do it right and get a used down pipe, cut the 'Subaru' branded cat out and weld over the 3inch down pipe. Each year this saves on a couple hours labour and headache of having to swap it out.
Anyway he showed me the emissions results after most recent PASS (Oct 2018) and they looked high to me but I couldn't easily find anywhere to show what it actually needed to pass.
my friend has a 3 inch full system (no cats) but decided to do it right and get a used down pipe, cut the 'Subaru' branded cat out and weld over the 3inch down pipe. Each year this saves on a couple hours labour and headache of having to swap it out.
Anyway he showed me the emissions results after most recent PASS (Oct 2018) and they looked high to me but I couldn't easily find anywhere to show what it actually needed to pass.
#53
Scooby Regular
#55
Scooby Regular
Join Date: Dec 2009
Location: Northants
Posts: 70
Likes: 0
Received 0 Likes
on
0 Posts
mine kept failing on emissions. my mechanic kept saying the cats were empty. i kept saying yeah right.
anyway last year i bought a new centre cat see if it would pass. it failed.
this year i bought a new front cat. it passed.
anyway last year i bought a new centre cat see if it would pass. it failed.
this year i bought a new front cat. it passed.
#56
Scooby Regular
most mot places are not even going to know if the centre section has a cat or not , it varies from car to car if they do i know fsti does not it only seems to have one cat , so if a tester asks if a centre section cat has been taken out then simple answer it’s not a cat , i thought the emissions being tightened up was more for diesels , my monaro will be fun as that only just scrapes through at the moment any way
#57
Scooby Regular
iTrader: (2)
My wr1 has scraped past the emissions for the last two years with the original prodrive sports cat. It’s due again now, so hopefully the pass numbers are still the same and not lower than last year. Don’t forget to make sure the cars nice and hot after a good run when you take it in.
#58
Scooby Regular
iTrader: (3)
My wr1 has scraped past the emissions for the last two years with the original prodrive sports cat. It’s due again now, so hopefully the pass numbers are still the same and not lower than last year. Don’t forget to make sure the cars nice and hot after a good run when you take it in.
My sports cat has passed since 09, just needs a little warming up, so launch control needs turning off, no bribes required.
Thread
Thread Starter
Forum
Replies
Last Post
Steve Whitehorn
ScoobyNet General
6
27 April 2007 11:31 PM